Product ID:TURCO 4909
MSDS Date:03/28/1990
FSC:6850
NIIN:00-282-6770
MSDS Number: BDTGQ

TURCO PRODUCTS, INC.

7300 BOLSA AVE
WESTMINSTER, CA 92634-3600
US

Emergency Phone: 614-387-6200

Info Phone: 714-890-3600

Preparer: JOHN P. JONES

Cage: 0BYN5

TURCO PRODUCTS, INC. DIVISON OF ELF ATOCHEM NORTH AMERICA

PHILADELPHIA, PA 19103-3222 US

Telephone: 215-419-7890

Cage: 61102

PHOSPHORIC ACID (SARA III)

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 5.0%

OSHA PEL 1 MG/M3/3 STEL

ACGIH TLV: 1 MG/M3/3 STEL; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 5.0%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

NONYLPHENOL POLYETHOXATE

CAS: 9016-45-9

RTECS: MD0900000

Fraction By Weight: 5.0%

GLYCOLS, POLYETHYLENE, MONO(P-(1,1,3,3-TETRAMETHYL

CAS: 9002-93-1

RTECS: MD0907700

Fraction By Weight: 5.0%

CITRIC ACID

CAS: 77-92-9

RTECS: GE7350000

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAN CAUSE SEVERE IRRITATION OR
BURNS TO EXPOSED TISSUE. CHRONIC:DAMAGE TO UPPER RESPIRATORY TRACT
OR G.I. OR TISSUE DAMAGE.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEE HEALTH HAZARDS DATA
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH PRE-EXISTING DISEASE INVOLVING THE RESPIRATORY TRACT MAY BE
AT INCREASED RISK FROM EXPOSURE.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE CPR.
CALL A PHYSICIAN. EYE: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER
FOR 15 MINUTES. CALL A PHYSICIAN. SKIN: WASH WITH PLENTY OF SOAP &
WATER. REMOVE CONTAMINATED CLOTHING/SHOES. INGESTION: DO NOT
INDUCE VOMITING. IF CONSCIOUS, GIVE 2 GLASSES OF WATER TO DRINK.
GIVE NOTHING BY MOUTH IF UNCONSCIOUS. CALL A PHYSICIAN.

Flash Point Method:TCC
Flash Point:60.0F,15.6C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE/EXCESSIVE HEAT MAY CAUSE PRODUCTION
OF HAZARDOUS DECOMPOSITION PRODUCTS.VAPORS ARE HEAVIER THAN AIR &
MAY TRAVEL ALONG THE GROUND TO BE IGNITED ELSEWHERE.

Spill Release Procedures:VENTILATE AREA.WEAR PROTECTVE EQUIP.ELEMINATE
IGN SOUCE.STOP LEAK W/O RISK.DIKE/CONTAIN SPILLAGE.WIPE UP OR
ABSORB SPILLAGE ONTO ABSORBENT MATL.RECOVER IN DRUMS/CONTNRS WHICH
ARE SUITABLE FOR SHIPMENT TO DISPOSAL LOCATIONS.

Handling and Storage Precautions:STORE AWAY FROM HEAT/IGN SOURCES.USE
CARE IN OPENING DRUMS TO AVOID SPURTING OF CONTENTS.PROTECT CNTNRS
AGAINST PHYSICAL DAMAGE.
Other Precautions:VAP HEAVR THAN AIR WILL TRAVL ALONG GRD COLLECTING IN
LOW AREAS SUCH AS SUMPS.PERSONS ENTERING THIS AREA SHOULD USE
PROTEC EQUIP & BE OBSERVD WHILE IN THE AREA;AVOID REPEATD CONT W
SKIN/EYES.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR DECISION LOGIC-PUBL ICATION NUMBER 87.108.
Ventilation:PROVIDE SUFFICIENT LOCAL EXHAUST VENTILATION TO CONTROL
INHALATION EXPOSURES BELOW OSHA'S PEL.
Protective Gloves:NEOPRENE OR RUBBER
Eye Protection:SAFETY GOGGLES & FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET ON SKIN, IN EYES OR ON CLOTHING. DO NOT BREATHE VAPORS OR
MISTS. WASH HANDS AND FACE AFTER USE. KEEP CONTAINER CLOSED WHEN
NOT IN USE.

HCC:F5
Boiling Pt:=82.2C, 180.F
Vapor Pres:APPROX. 20
Vapor Density:>1.0
Spec Gravity:1.052
Evaporation Rate & Reference:>1.0 (BU. AC.=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID, KETONE ODOR.
Percent Volatiles by Volume:76

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALIS, REACTIVE METALS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:MAY EMIT FUMES OF OXIDES OF
PHOSPHORUS, CARBON MONOXIDE, AND CARBON DIOXIDE

Waste Disposal Methods:MFGR RECOMMENDS ONE OR ALL OF THE FOLLOWING
METHODS:(1) INCINERTE IN AN APPRVD INCINERATOR W APPROPRIATE FUME
SCRUBBER;(2) LANDFILL IAW LOCAL,STATE,FED REGS;(3) TRANSFER/SHIP TO
RECLAIMING FACILITY FO R SOLVENT RECOVERY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.